胡志远，张凤珍，张福强，陈争，楼狄明.柴油机使用再生润滑油的摩擦学性能试验研究[J].内燃机工程,2017,38(6):152-156.
柴油机使用再生润滑油的摩擦学性能试验研究
Experimental Study on Tribological Property of Regenerative Lubricating Oil Used in Diesel Engines
DOI：
关键词:柴油机  再生润滑油  摩擦学性能  摩擦功
Key Words:diesel engine  regenerative lubricating oil  tribological properties  friction work
基金项目:上海市科委科技攻关计划项目（14231201502）
作者单位
胡志远，张凤珍，张福强，陈争，楼狄明 1.同济大学 汽车学院，上海 201804；2. 克鲁勃润滑剂（上海）有限公司, 上海 201700 
摘要点击次数: 2092
全文下载次数: 1565
摘要:为验证发动机使用再生润滑油的可行性，以某公交车柴油机用15W 40润滑油为研究对象，开展了再生润滑油理化指标、摩擦学性能和发动机摩擦功试验。结果表明：再生润滑油的理化指标与原润滑油处于同一水平，满足GB11122—2006中黏度等级15W-40柴油机润滑油的黏温性能、抗氧化性能等要求。与原15W-40润滑油相比，再生15W-40润滑油的磨斑直径相对较大，钢球磨斑形貌表面的犁沟相对较长、较深，划痕相对较宽，极压润滑性能相对较差。热机倒拖时，发动机使用两种润滑油的摩擦功相当；冷机倒拖时，再生15W-40润滑油的摩擦功略有降低。
Abstract:The experimental study on the physical chemical index, tribological property and engine friction work was carried out to verify the feasibility of using the regenerative lubricating oil for bus diesel engines. Results show that the physical and chemical characteristics of the regenerative lubricating oil are at the same level with the 15W 40 lubricating oil used by the original engines, which can meet the requirements of viscosity temperature and anti oxidation properties, etc. of 15W-40 lubricating oil specified in GB 1122—2006.Compared with the original lubricating oil, use of regenerative lubricating oil will not only produce larger wear scars, longer and deeper furrows, and wider scratches, but also make the extreme pressure lubrication performance worse. In hot motoring test, the engine using the two kinds of lubricating oil has basically the same friction work, while in cold motoring test, the use of regenerative lubricating oil will cause a slight reduction in friction work.
查看全文  HTML   查看/发表评论